In an April 2010 White Paper, I proposed the focus should be on a vehicle with a 30 to 50 mile battery range and a range extender. The driving range was supported by a three year trip generation study of a single family use of multi vehicles. There was very little use over 50 miles (16% worst case) but this must be recongnized in the user psychology. The system was to have the minimum battery for the selected range and the range extender should match the required capacity (approximately 20kW).
The range extender is: 1) cheaper than the battery required to replace it, 2) support to the psychology of the user, 3) very efficient when designed and operated at a specific load and constant speed, 4) shut down when the battery charging is not required and 5) back up for a failing or failed battery. While any engine runs best under these conditions, a new concept called the CV Engine is 1/4 the size, twice as efficient and less pollution (for equal power). This improvement moves the cost of electricity closer to home utility charging and may be less than "on the road" charging. There is more but to much for a thread.
The USPTO issued their Notice of Allowance to Issue a Patent on 09-12-12 for the CV Engine/Technology. More to come later perhaps as article in Design News.
The fact that you disagree with this article doesn't mean that UBM articles are biased, CharlesM. Moreover, your accusation about Chevy Volt battery fire stories couldn't be more inaccurate. During the media-wide spread of battery fire stories, we were the ones that pointed out -- repeatedly -- that there was nothing to worry about.
Regarding our Avnet Drive for Innovation: Editor Brian Fuller has toured the country with the Volt, driven it up Pikes Peak, and written a boatload of positive stories about it. When I reviewed the Volt, I called it an "astonishing vehicle, a lot of fun to drive, yet stingy in its use of energy." We've also done a similar positive review on the Prius PHV.
Oh, and there's also our Engineer of the Year award three years ago: We nominated JB Straubel of Tesla Motors, named him the winner, and wrote a four-page magazine piece about his efforts. See "Tesla Engineer Boosts EV Range to New Heights," http://www.designnews.com/document.asp?doc_id=228520.
If that shows a "drumbeat" of bias against EVs and sustainability, then we sure have a funny way of showing it.
But how do we get the costs of new technologies down without economies of scale which cannot occur without demand? This is the chicken-egg syndrome that only government can solve. That's why there are gov't cost incentives for early adapters, who are still willing to pay more and accept early technology risks. But only this way can the costs and reliability issues of mass production be solved. We can't wait for a magic cold fusion-esque breakthrough to occur (fuel cells, anyone?), and even if that does occur the transition of whatever that is to mass production will still be costly and unreliable until significant deployment happens.
Meanwhile you're always free to not be an early adapter and buy for only your pocketbook. In that case, your best bet is a used car with maybe 40k miles already on it, a small economy four cylinder. Most everything else is just throwing your money away. You can get one with a turbo if you want performance (--but why, given your frugalness?).
You know many of the EV bashers have never been in one. Our Leaf is perfect for my wife's commute, she makes it to work, school, and back to the house no problem. I can't emphasize enough how great it is to start with a full tank every morning, just unplug the car (in a comfortable garage) and go. Never late to work because you are low on gas. I'm sure it is self indulgent, but as it turns out, many MANY vehicles out there are indulgent. I've posted before that I have two children in the Army, and they have both been deployed in the middle east recently. If you don't think they are protecting our oil supply, you are kidding yourself. Iran would fill the vacuum if we pulled our Navy fleet out of the waters surrounding the middle east, and oil prices would skyrocket. So tax dollars for this or tax dollars for that, I'd prefer to use my Kentucky coal miner powered Leaf over any OPEC oil powered ice any day. We are so close to the solution that gets us off the OPEC drug, using home grown oil, NG, coal, solar, wind, hydro, so close.
OMG wake up and look around. Here in the US oil companies have been getting corporate welfare for over 100 years. In the recent past this corporate welfare is in the billions of dollars. Worldwide automakers are almost universally receiving substantial government assistance. This includes companies like Toyota, Nissan, Volkswagen, Mercedes-Benz, Hyundai, Kai and many more. Yet you think US companies don't deserve the equal footing with their worldwide competitors. There's a time and a place for government assistance. Oil companies don't need that assistance anymore but new emerging technologies are the way technology has been commercialized since the dawn of civilization. It's like going to a fight where are your right hand is tied behind your back and you have a 20 pound weight attached to your left leg, not a fair fight.
There should be no government involvement in the marketplace. Period! Let supply drive demand. It has always worked in the past.
That may be funny, but it's not grounded in reality. The world spends $775 billion per year in subsidies for fossil fuels. And OPEC, an illegal cartel, influences oil prices by modulating supply. How is the market "free"?
There is one company that I know of that is actually deploying battery swap stations in several countries on a trial basis. see: http://www.betterplace.com/
While the concept has some issues (eg. how do you guarantee that every battery pack is as good as the original?) - it seems pretty workable and practical.
There is a bigger issue, however. Most people (esp. non-technical zealots like some posters here) seem to ASSUME that EV's are the future, if only the cost can be brought down. They think that EV's are automatically the best solution, that they are "obviously" zero emissions. Clear thinkers, in contrast, study the details to understand the bigger picture - that EV's are only as "clean" as the power grid that charges them. The batteries are the weak link, with high cost and also rare, expensive, often caustic chemicals, and a huge issue with useful battery life and recycling old ones.
I think the fundamental question needs to be asked (and answered) - what, exactly, is the problem that EV's are supposedly solving? If it is to get us off of fossil fuels - they don't really do that (with today's avg. power grid)...only shifting fuel from oil to mainly coal+natural gas. If THAT were the main goal, we could easily shift ICE cars to run on natural gas or coal-based synfuel (as China already is). In the more distant future, solar-created synfuels could be used - eliminating the need to further burden the electric grid or have massive batteries, yet acheiving 100% renewable power for cars and all the infastructure, range and convenience as today's cars.
I think that hybrid cars make much more sense than EV's because they acheive fantastic MPG gains in city driving, yet make do with frugally small batteries (and maybe in the near future - ultracapacitors instead of batteries). They are the best balance of efficiency, range, practicality and economics. THAT is the reason that Toyota is not very interested in pure EV's - as the hybrid leader they are aware of these facts.
In the end, once the distortions from the massive government support spending on EV's stops - what will drive the mass market is ECONOMICS. EV's are just a passing fad for mainstream cars, but will probably remain a viable solution for short-range city cars and taxis.
It comes as no surprise that the battery is limiting the acceptance of electric only cars. I have been slogging my way through an electric conversion for two years now and have gained a greater respect for the technical challenge of electric only transportation. Range and battery safety/reliability/longevity is without doubt the most significant challenge to overcome. My conversion platform is a 1972 SAAB 99.
I have coined a term, EVgallon, which represents the amount of battery capacity necessary to produce approximately the same result in an ICE vehicle. An EVgallon comes out to be 6KWh. My LiFePO4 battery weighs 150 lbs takes up nearly the entire volume of the former gas tank and yet holds only one EVgallon of charge. So, my vehicle, when completely charged, can go approximately as far as the original vehicle with 1 gallon of gas in the tank.
This actually works just fine for driving the kids to school, or athletic practice, or doing a grocery run. It charges in about 1.5 hours off of a 220v 15 amp service, so it is very functional in that way. However, there is no way in He!! that this technology is going to challenge an ICE vehicle for long range or heavy load operation. Replaceable battery packs is really not practicle either as one "gallons" worth of batteries is 150 lbs. I don't seem many "Leaf" owners lifting six 75 lbs blocks in and out of their vehicles. Also notice that the Toyota pluggable EV has less than one gallon capacity. This probably explains Toyota's reluctance to make its hybrid pluggable. A lot of additional electronics to accomplish little additional vehicle ability.
I have owned electric scooters and electric motor bikes, which seem to perform much closer to their ICE counterparts, so maybe there is where the emerging market really is.
For now, EV is probably constrained to short run haulers. My wish is that the tax credits would stop but that legislation would be initiated to give insurance breaks so that there is no inherent penalty for having multiple vehicles for different purpose. Having a vehicle devoted to kid hauling would be wonderful. This mode of use is probably the least efficient for ICEs and the most plausible for EVs.
Re-aligning the insurance issue could go along way toward supporting the manufacture and sales of this specific purpose additional vehicle market.
In honor of Earth Day, the National Security Agency has launched the STEM Recycling Challenge in Maryland schools to encourage kids to think about where the garbage they throw out every day actually goes. The agency has also introduced “Dunk,” a muscular blue cartoon recycling bin wearing shorts and sneakers.
A slew of announcements about new materials and design concepts for transportation have come out of several trade shows focusing on plastics, aircraft interiors, heavy trucks, and automotive engineering. A few more announcements have come independent of any trade shows, maybe just because it's spring.
Focus on Fundamentals consists of 45-minute on-line classes that cover a host of technologies. You learn without leaving the comfort of your desk. All classes are taught by subject-matter experts and all are archived. So if you can't attend live, attend at your convenience.