<<  <  Page 2/2
Beth Stackpole
User Rank
Re: Fire hazzard
Beth Stackpole   12/1/2011 6:47:38 AM
I have to agree with TIm that this is more likely a case of fear being raised over a relatively new and unknown technology rather than a some sort of sustainable threat. Yet it does give me cause for concern and make me wonder about additional design considerations that could help protect against the fire threat, however small. There is actually some precedent--several years back, I remember an Apple recall on littium ion battieries used in its laptops because there were reports of them catching fire. I'm wondering if there are parallels?

User Rank
Lithium is Reliable and safe
JimT@Future-Product-Innovations   11/30/2011 11:12:32 PM

It was 1997 and I had just seen my very first Lithium cell pack for a cell phone.  I was the Accessories Products Development Engineering Manager for the Motorola iDEN phones.  We had recently migrated from the long-standing NiCd batteries to Nickel Metal  Hydride (NmH) technology as a green initiative to eliminate Cadmium, but that initiative was short-lived as Lithium promised higher capacities and greater number of  charge/discharge cycles, although costing a bit more than the NiCd or the NmH.  500 million cell packs later, the only fires or faults we had documented were due to non-standard charging equipment; usually from a Chinese 3rd party knock-off charger that didn’t include the proper thermistors or relevant safety circuitry.  Its like Nuclear Power.  Follow the rules established and it will serve dutifully. I hate to see Li-Ion get a bad rap.

TJ McDermott
User Rank
Re: Fire hazzard
TJ McDermott   11/30/2011 10:33:37 PM
One can imagine the hysteria if hydrogen becomes a viable fuel for domestic use.   Dual dangers of flammability and extreme cold would cause headlines like "Freeze and Burn at the Same Time!"

Charles Murray
User Rank
Charles Murray   11/30/2011 10:33:09 PM
There's always been far too much hype around electric vehicles and lithium-ion batteries, and the recent Volt fires are no exception to that. Yes, the electrolyte in lithium batteries is a highly flammable liquid but, as Brian points out, there's nothing new about that. We've known about it for a long time. The truth is, we really don't have any reliable details on the cause of these fires, but we can definitely say this: If an improperly-constructed gasoline-burning car had burst into flames, it would have been a far worse accident, and it would have happened a lot faster than three weeks.

User Rank
Fire hazzard
Tim   11/30/2011 6:32:45 PM
I really do not know if the LiON batteries catch fire.  I find it hard to imagine that Volts randomly burst into flames, but I can guarantee that gasoline which is the alternative to batteries is higly flammable,  A spark while fueling has a real chance of igniting vapors of gasoline.  However, it is still common to see people smoking while filling up at the local 7-Eleven.  This seems to be a case of fear of new technology showing fears that may or may not be warranted.

Jerry dycus
User Rank
Re: Tempest
Jerry dycus   11/30/2011 2:54:43 PM

  Like gasoline, Batteries hold a lot of energy so if damaged, could short and cause a fire.  But how many Fords cause so many fires from ignition switches!!

And each car already has batteries and fires from them haven't been much of a problem.  But dying in gasoline fires, yes a real problem. EV's ones, not so much.

And it's the electric power causing the fires mostly, not the batteries bursting into flames.

And few Lithium batts use flameable electrolyte anymore. Most can be shot with bullets without causing problems so all in all, EV fires are rare and likely to stay that way.

Alexander Wolfe
User Rank
Alexander Wolfe   11/30/2011 11:26:54 AM
There's always an aspect to these stories where they take on a life of their own, regardless of what the facts turn out to be. A case in point is the Toyota unintended acceleration of a few years ago. The more distance one gets from that, the more it looks like driver error was the cause in a lot of so-called instances. Not saying that's the case here, but I am saying, as Brian notes, we need to wait for a full investigation before jumping to conclusions. For example, if you looked at 100 percent of charging systems for everything, you'd find some fires.

<<  <  Page 2/2

Partner Zone
Latest Analysis
Advertised as the "Most Powerful Tablet Under $100," the Kindle Fire HD 6 was too tempting for the team at iFixit to pass up. Join us to find out if inexpensive means cheap, irreparable, or just down right economical. It's teardown time!
The first photos made with a 3D-printed telescope are here and they're not as fuzzy as you might expect. A team from the University of Sheffield beat NASA to the goal. The photos of the Moon were made with a reflecting telescope that cost the research team 100 to make (about $161 US).
At Medical Design & Manufacturing Midwest, Joe Wascow told Design News how Optimal Design prototyped a machine that captures the wing-beat of a duck.
The increased adoption of wireless technology for mission-critical applications has revved up the global market for dynamic electronic general purpose (GP) test equipment. As the link between cloud networks and devices -- smartphones, tablets, and notebooks -- results in more complex devices under test, the demand for radio frequency test equipment is starting to intensify.
Much of the research on lithium-ion batteries is focused on how to make the batteries charge more quickly and last longer than they currently do, work that would significantly improve the experience of mobile device users, as well EV and hybrid car drivers. Researchers in Singapore have come up with what seems like the best solution so far -- a battery that can recharge itself in mere minutes and has a potential lifespan of 20 years.
Design News Webinar Series
10/7/2014 8:00 a.m. California / 11:00 a.m. New York
9/25/2014 11:00 a.m. California / 2:00 p.m. New York
9/10/2014 11:00 a.m. California / 2:00 p.m. New York
7/23/2014 11:00 a.m. California / 2:00 p.m. New York
Quick Poll
The Continuing Education Center offers engineers an entirely new way to get the education they need to formulate next-generation solutions.
Oct 20 - 24, How to Design & Build an Embedded Web Server: An Embedded TCP/IP Tutorial
SEMESTERS: 1  |  2  |  3  |  4  |  5  |  6

Focus on Fundamentals consists of 45-minute on-line classes that cover a host of technologies. You learn without leaving the comfort of your desk. All classes are taught by subject-matter experts and all are archived. So if you can't attend live, attend at your convenience.
Next Class: 10/28-10/30 11:00 AM
Sponsored by Stratasys
Next Class: 10/28-10/30 2:00 PM
Sponsored by Gates Corporation
Next Class: 11/11-11/13 2:00 PM
Sponsored by Littelfuse
Learn More   |   Login   |   Archived Classes
Twitter Feed
Design News Twitter Feed
Like Us on Facebook

Sponsored Content

Technology Marketplace

Copyright © 2014 UBM Canon, A UBM company, All rights reserved. Privacy Policy | Terms of Service