Electronics & Test

Lithium-Ion Batteries Emerge as Possible Culprit in Dreamliner Incidents

Page 1 / 2 Next >
View Comments: Oldest First|Newest First|Threaded View
Page 1/4  >  >>
Cabe Atwell
User Rank
Cabe Atwell   1/17/2013 3:20:15 PM
They obviously overlooked the battery design slightly in the initial stages of development. At least no one was hurt, but I am sure Boeing will fire a few on the battery team. With all the battery exploding incidents from the past, I am surprised that wasn't a concern for the engineering team. However, it could have been a manufacturing error.. Time will tell.


User Rank
Dreamliner Batteries
apresher   1/17/2013 5:26:21 PM
Chuck, Very interesting report.  It's amazing how with a system as complex as the Dreamliner, there are a very large number of unknown variables to resolve.  Tough for the Boeing engineers who are moving a project of this scope into the marketplace, especially in a spotlight as bright as this situation. 

Charles Murray
User Rank
Re: Dreamliner Batteries
Charles Murray   1/17/2013 5:43:49 PM
I agree, Al. The spotlight is very bright in this case. I initially wondered if the bright spotlight might be part of the problem here. But the succession of battery overheating incidents in January alone is hard to ignore.  

Jack Rupert, PE
User Rank
Re: Dreamliner Batteries
Jack Rupert, PE   1/17/2013 10:02:32 PM
It's interesting that this is the same technology that Ford just standardized on.  While the article mentions the cooling systems used in autos and some of the other design components, I can't help but wonder what can happen a few years down the road in vehicles that are not properly maintained...whatever the definition of "properly" may be with respect to battery safety.

User Rank
Re: Dreamliner Batteries
gafisher   1/18/2013 9:39:12 AM
Lithium-Ion chemistry is also used in the Chevy Volt, the Fisker and other electric vehicles (but notably not in the Toyota Prius).  Li-ion is a very energetic chemistry, which is necessary to pack so much energy in a limited volume.  Gasoline is even more efficient, so much so that it can explode in situations where Li-ion batteries would only burn.

User Rank
Cooling at 30,000 ft.?
SystemsGuy   1/18/2013 9:39:44 AM
How hard can it be to cool batteries when the outside temperature at 30,000 ft is below (-60F) ?

User Rank
Re: Dreamliner Batteries
ChasChas   1/18/2013 9:44:45 AM
I look at that tight battery box and think - you cannot cool an adiabatic heat source with it's own energy - inside of the system.

User Rank
What type of lithium ion batteries?
davemiga   1/18/2013 9:47:51 AM
The description of the meltdown seems that they might be using lithium cobalt, not a good design choice if that is the case. Lithium iron phosphate LiFeP04 would be the only safe choice. Anyone know what Boeing used?

Charles Murray
User Rank
Re: What type of lithium ion batteries?
Charles Murray   1/18/2013 9:53:22 AM
Very good point, davemiga. I've heard -- unofficially -- that it was cobalt, but haven't been able to verify it. And, yes, a cobalt chemistry is slightly more susceptible to overheating, although all lithium-ion chemistries are on the edge (with the possible exception of the so-called "nanophophate" chemistries).

User Rank
Re: fired
ScotCan   1/18/2013 9:53:49 AM
Liaison engineers have commented previously that Boeing may have done too much too soon with this aircraft. 

We have had lithium systems problems in E scooters where thermal overload shut down the 48V system via the batteries management software. We concluded that heavy current draw during acceleration was causing the problem and tried conditioning that by tweaking the controller 

Page 1/4  >  >>
Partner Zone
Latest Analysis
Designers of electronic interfaces will need to be prepared to incorporate haptics in next generation products, an expert will tell attendees at the upcoming Designer of Things Conference in San Jose.
According to a Randstad Engineering compilation of salary studies, engineering salaries are increasing beyond inflation, with employers paying to keep potential suitors away from their employees.
The company says it anticipates high-definition video for home security and other uses will be the next mature technology integrated into the IoT domain, hence the introduction of its MatrixCam devkit.
Siemens and Georgia Institute of Technology are partnering to address limitations in the current additive manufacturing design-to-production chain in an applied research project as part of the federally backed America Makes program.
Most of the new 3D printers and 3D printing technologies in this crop are breaking some boundaries, whether it's build volume-per-dollar ratios, multimaterials printing techniques, or new materials types.
Design News Webinar Series
11/10/2015 11:00 a.m. California / 2:00 p.m. New York
10/29/2015 11:00 a.m. California / 2:00 p.m. New York
10/20/2015 8:00 a.m. California / 11:00 a.m. New York
12/2/2015 11:00 a.m. California / 2:00 p.m. New York
Quick Poll
The Continuing Education Center offers engineers an entirely new way to get the education they need to formulate next-generation solutions.
Jul 6 - 10, Building Raspberry Pi Controllers with Python
SEMESTERS: 1  |  2  |  3  |  4  |  5  |  6 |  7

Focus on Fundamentals consists of 45-minute on-line classes that cover a host of technologies. You learn without leaving the comfort of your desk. All classes are taught by subject-matter experts and all are archived. So if you can't attend live, attend at your convenience.
Learn More   |   Login   |   Archived Classes
Twitter Feed
Design News Twitter Feed
Like Us on Facebook

Sponsored Content

Technology Marketplace

Copyright © 2015 UBM Canon, A UBM company, All rights reserved. Privacy Policy | Terms of Service