Electronics & Test

Lithium-Ion Batteries Emerge as Possible Culprit in Dreamliner Incidents

< Previous Page 2 / 2
View Comments: Oldest First|Newest First|Threaded View
Page 1/4  >  >>
Cabe Atwell
User Rank
Cabe Atwell   1/17/2013 3:20:15 PM
They obviously overlooked the battery design slightly in the initial stages of development. At least no one was hurt, but I am sure Boeing will fire a few on the battery team. With all the battery exploding incidents from the past, I am surprised that wasn't a concern for the engineering team. However, it could have been a manufacturing error.. Time will tell.


User Rank
Dreamliner Batteries
apresher   1/17/2013 5:26:21 PM
Chuck, Very interesting report.  It's amazing how with a system as complex as the Dreamliner, there are a very large number of unknown variables to resolve.  Tough for the Boeing engineers who are moving a project of this scope into the marketplace, especially in a spotlight as bright as this situation. 

Charles Murray
User Rank
Re: Dreamliner Batteries
Charles Murray   1/17/2013 5:43:49 PM
I agree, Al. The spotlight is very bright in this case. I initially wondered if the bright spotlight might be part of the problem here. But the succession of battery overheating incidents in January alone is hard to ignore.  

Jack Rupert, PE
User Rank
Re: Dreamliner Batteries
Jack Rupert, PE   1/17/2013 10:02:32 PM
It's interesting that this is the same technology that Ford just standardized on.  While the article mentions the cooling systems used in autos and some of the other design components, I can't help but wonder what can happen a few years down the road in vehicles that are not properly maintained...whatever the definition of "properly" may be with respect to battery safety.

User Rank
Re: Dreamliner Batteries
gafisher   1/18/2013 9:39:12 AM
Lithium-Ion chemistry is also used in the Chevy Volt, the Fisker and other electric vehicles (but notably not in the Toyota Prius).  Li-ion is a very energetic chemistry, which is necessary to pack so much energy in a limited volume.  Gasoline is even more efficient, so much so that it can explode in situations where Li-ion batteries would only burn.

User Rank
Cooling at 30,000 ft.?
SystemsGuy   1/18/2013 9:39:44 AM
How hard can it be to cool batteries when the outside temperature at 30,000 ft is below (-60F) ?

User Rank
Re: Dreamliner Batteries
ChasChas   1/18/2013 9:44:45 AM
I look at that tight battery box and think - you cannot cool an adiabatic heat source with it's own energy - inside of the system.

User Rank
What type of lithium ion batteries?
davemiga   1/18/2013 9:47:51 AM
The description of the meltdown seems that they might be using lithium cobalt, not a good design choice if that is the case. Lithium iron phosphate LiFeP04 would be the only safe choice. Anyone know what Boeing used?

Charles Murray
User Rank
Re: What type of lithium ion batteries?
Charles Murray   1/18/2013 9:53:22 AM
Very good point, davemiga. I've heard -- unofficially -- that it was cobalt, but haven't been able to verify it. And, yes, a cobalt chemistry is slightly more susceptible to overheating, although all lithium-ion chemistries are on the edge (with the possible exception of the so-called "nanophophate" chemistries).

User Rank
Re: fired
ScotCan   1/18/2013 9:53:49 AM
Liaison engineers have commented previously that Boeing may have done too much too soon with this aircraft. 

We have had lithium systems problems in E scooters where thermal overload shut down the 48V system via the batteries management software. We concluded that heavy current draw during acceleration was causing the problem and tried conditioning that by tweaking the controller 

Page 1/4  >  >>
Partner Zone
Latest Analysis
General Motors is putting an off-road twist on hydrogen fuel cell technology with an imposing new pickup demonstrator called the Chevrolet Colorado ZH2.
Fine powder printing of industry-standard metal and ceramic powders with a grain size of less than 10 microns is now available from industrial 3D printer maker ExOne for its Innovent printer.
At ARM TechCon 2016, CEO Simon Segars will discuss how he sees billions of devices scaling to trillions as IoT applications proliferate. We know it’s happening. How do we prepare?
The term “autopilot” is now at the heart of a growing debate between Tesla Motors Inc. and Germany’s Federal Motor Transport Authority.
A make-your-own Star Wars Sith Lightsaber hilt is heftier and better-looking than most others out there, according to its maker, Sean Charlesworth. You can 3D print it from free source files, and there's even a hardware kit available -- not free -- so you can build one just in time for Halloween.
Quick Poll
The Continuing Education Center offers engineers an entirely new way to get the education they need to formulate next-generation solutions.
Oct 10 - 14, Embedded System Design Techniques™: Getting Started Developing Professional Embedded Software
SEMESTERS: 1  |  2  |  3  |  4  |  5  |  6 |  7 | 8 | 9 | 10

Focus on Fundamentals consists of 45-minute on-line classes that cover a host of technologies. You learn without leaving the comfort of your desk. All classes are taught by subject-matter experts and all are archived. So if you can't attend live, attend at your convenience.
Next Course September 27-29:
Sponsored by 3M
Learn More   |   Login   |   Archived Classes
Twitter Feed
Design News Twitter Feed
Like Us on Facebook

Technology Marketplace

Copyright © 2016 UBM Canon, A UBM company, All rights reserved. Privacy Policy | Terms of Service