I own a 1998 Monaco Safari Trek motor home -- a Class A (boxy structure), gasoline-powered, recreational vehicle. I could go on for pages about all the little things that went into (or didn't go into) the construction of this vehicle. My friends joke that I am the only person they know who would disassemble a new motor home in order to fix it.
I went through a rough period where the engine would just quit, usually at very inopportune times. Or, the vehicle would start running lean, forcing the computer into an open-loop mode to keep the engine running. I think I fried a catalytic converter running it that way once.
The vehicle is equipped with OBDII (check engine codes), but it doesn't provide fuel pressure as a reading. The symptoms pointed to a plugged fuel filter or a bad fuel pump.
The fuel pump is located inside the gas tank, so it's not the easiest thing to service. I had it replaced once. I went to fill up with gas, only to have the gas start gushing out from the top of the tank. I guess it was a trick to get the gasket correctly placed for the pump, and you didn't know it was incorrectly placed until you tried filling the tank. So now I had a full tank (60 gallons) that had to be drained so I could work on the pump.
Worst of all, the fuel filter is buried up inside a chassis rail, right above a 12V DC distribution panel that has lots of hot, exposed cable ends. It's hard to reach, and there is very little space to work. There is barely room to get a wrench onto the nuts holding the fuel filter canister. Plus, when you loosen the filter, gas flows out over the power cables. It would only take a slip of the wrench to short out one of the exposed connections, sparking the gas into a nice little fire. There is no way to cut off the power short of disconnecting all the batteries and covering the solar panel with a blanket.
This was the worst possible place they could have located the fuel filter. Definitely Made by Monkeys.
This entry was submitted by David Lippincott and edited by Rob Spiegel.
Tell us your experiences with Monkey-designed products. Send stories to Rob Spiegel for Made by Monkeys.
Related posts:
Tweet This
7 
